Optimization of Tannic Acid Polymerization to Improve the Efficiency of Dye-Sensitized Solar Cells: Effect of Temperature and Monomer Concentration
DOI:
https://doi.org/10.25077/jrk.v16i2.823Keywords:
DSSC, Polymerization, Tanic Acid, Titanium Dioxide, CrosslinkingAbstract
This study investigates the effects of temperature and monomer concentration on tannic acid polymerization to enhance dye-sensitized solar cell (DSSC) efficiency. Tannic acid was polymerized using Trimethylolpropane Triglycidyl Ether (TMPGDE) as a crosslinker, with monomer concentrations of 2, 2.5, and 3 grams and temperatures ranging from 30°C to 110°C. UV-Vis analysis revealed a bathochromic shift in poly-tannic acid, indicating increased light absorption in the 200-800 nm range. FTIR confirmed the formation of new ether groups, signifying successful polymerization. The highest DSSC efficiency (8.984%) was achieved with 2.5 grams of monomer at 50°C, significantly outperforming unpolymerized tannic acid (1.35%). The optimal poly-tannic acid has an average molecular weight of 32,610.1568 and a polymerization degree of 19.182. This research demonstrates the potential of tannic acid polymerization for improving DSSC performance, paving the way for more efficient and cost-effective organic solar cells.
References
1. Resosudarmo BP, Rezki JF, Effendi Y. Prospects of Energy Transition in Indonesia. Bull Indones Econ Stud. 59(2):149–77 (2023).
2. Saputri NK, Setyonugroho LD, Hartono D. Exploring the determinants of energy poverty in Indonesia’s households: empirical evidence from the 2015–2019 SUSENAS. Humanit Soc Sci Commun. 11(1):60 (2024).
3. Renewable Energy Agency I. Socio-economic footprint of the energy transition: Indonesia [Internet]. Available from: www.irena.org (2023).
4. Liu Z, Deng Z, Davis S, Ciais P. Monitoring global carbon emissions in 2022. Nat Rev Earth Environ. 4(4):205–6 (2023).
5. Lv Y. Transitioning to sustainable energy: opportunities, challenges, and the potential of blockchain technology. Front Energy Res. 11 (2023).
6. Hardeli H, Sanjaya H;, Permatasari P, Karnila R. Improvement of Solar Cell Performance by Annealing Temperature Treatment and Active Layer Ratio. J Chem Chem Eng Research Article. 41(11):3918–28 (2022).
7. Hardeli, Sanjaya H, Permatasari P, Karnila R. Improvement of Solar Cell Performance by Annealing Temperature Treatment and Active Layer Ratio. Vol. 41, J. Chem. Chem. Eng. Research Article. (2022).
8. Hardeli, Hijri F, Sanjaya H, Putri YP, Permatasari P. The effect of coating in increasing the efficiency of solar cells by using quercetin poly as a dye. Rasayan Journal of Chemistry. 16(3):1925–31 (2023).
9. Hardeli, Sanjaya H, Permatasari P, Novita IP, Agdisti NF, Luli R, et al. TiO2-Ag and natural dye co-pigmented with salicylic acid for dye-sensitized solar cell (dssc) application. Rasayan Journal of Chemistry. 15(1):569–78 (2022).
10. Dada M, Popoola P, Alao A, Olalere F, Mtileni E, Lindokuhle N, et al. Functional materials for solar thermophotovoltaic devices in energy conversion applications: a review. Front Energy Res. 11 (2023).
11. Asahi S, Teranishi H, Kusaki K, Kaizu T, Kita T. Two-step photon up-conversion solar cells. Nat Commun. 8(1):14962 (2017).
12. Irnawan RF, Ismail Y. Energy transition: Utilization of solar energy as an energy source in smart building implementation as an effort to reduce the use of fossil energy. Journal of Innovation Materials, Energy, and Sustainable Engineering. 1(2) (2024).
13. J. A. A Review on the Third-Generation Solar Cells: Model, Materials, and Performance. International Journal of Research and Innovation in Applied Science. IX(I):219–27(2024).
14. De A, Bhattcharjee J, Chowdhury SR, Roy S. A Comprehensive Review on Third-Generation Photovoltaic Technologies. Journal of Chemical Engineering Research Updates. 10:1–17 (2023).
15. Shah N, Shah AA, Leung PK, Khan S, Sun K, Zhu X, et al. A Review of Third Generation Solar Cells. Processes. 11(6):1852 (2023).
16. Kokkonen M, Talebi P, Zhou J, Asgari S, Soomro SA, Elsehrawy F, et al. Advanced research trends in dye-sensitized solar cells. J Mater Chem A Mater. 9(17):10527–45 (2021).
17. Rahman S, Haleem A, Siddiq M, Hussain MK, Qamar S, Hameed S, et al. Research on dye sensitized solar cells: recent advancement toward the various constituents of dye sensitized solar cells for efficiency enhancement and future prospects. RSC Adv. 13(28):19508–29 (2023).
18. Malhotra SS, Ahmed M, Gupta MK, Ansari A. Metal-free and natural dye-sensitized solar cells: recent advancements and future perspectives. Sustain Energy Fuels. 8(18):4127–63 (2024).
19. Kim MR, Pham TC, Yang HS, Park SH, Yang S, Park M, et al. Photovoltaic Effects of Dye-Sensitized Solar Cells Using Double-Layered TiO 2 Photoelectrodes and Pyrazine-Based Photosensitizers. ACS Omega. 8(16):14699–709 (2023).
20. Daniel LS, Kaffer RT, Kalipi LM, Rahman A, Kalengay M, Uahengo V. The photon‐electrical conversion efficiency of dye‐sensitive solar cells fabricated using a highly conductive silver‐nanoparticle/titania photocathode. Applied Research. 3(1) (2024).
21. Mariotti N, Bonomo M, Fagiolari L, Barbero N, Gerbaldi C, Bella F, et al. Recent advances in eco-friendly and cost-effective materials towards sustainable dye-sensitized solar cells. Green Chemistry.22(21):7168–218 (2020).
22. Pratiwi M, Kalsum L, Rusdianasari R. Revolutionizing Dye Sensitized Solar Cells – Impact of Silicon Dioxide Purity Derived from Coal Fly Ash for Enhanced Photoelectric Performance. Journal of Ecological Engineering. 25(11):210–20 (2024).
23. Sharma K, Sharma V, Sharma SS. Dye-Sensitized Solar Cells: Fundamentals and Current Status. Nanoscale Res Lett. 13(1):381 (2018).
24. Kim JH, Park SY, Lim DH, Lim SY, Choi J, Koo HJ. Eco-Friendly Dye-Sensitized Solar Cells Based on Water-Electrolytes and Chlorophyll. Materials. 14(9):2150 (2021).
25. Joly D, Pellejà L, Narbey S, Oswald F, Chiron J, Clifford JN, et al. A Robust Organic Dye for Dye Sensitized Solar Cells Based on Iodine/Iodide Electrolytes Combining High Efficiency and Outstanding Stability. Sci Rep. 4(1):4033 (2014).
26. Bekele ET, Sintayehu YD. Recent Progress, Advancements, and Efficiency Improvement Techniques of Natural Plant Pigment‐Based Photosensitizers for Dye‐Sensitized Solar Cells. J Nanomater. 2022(1) (2022).
27. Dhorkule M, Lamrood P, Ralegankar S, Patole SP, Wagh SS, Pathan HM. Unveiling the Efficiency of Dye-Sensitized Solar Cells: A Journey from Synthetic to Natural Dyes. ES Food & Agroforestry. (2024).
28. Zdyb A, Krawczak E. Organic Dyes in Dye-Sensitized Solar Cells Featuring Back Reflector. Energies (Basel). 14(17):5529 (2021).
29. Calogero G, Bartolotta A, Di Marco G, Di Carlo A, Bonaccorso F. Vegetable-based dye-sensitized solar cells. Chem Soc Rev. 44(10):3244–94 (2015).
30. Diantoro M, Suprayogi T, Taufiq A, Fuad A, Mufti N. The Effect of PANI Fraction on Photo Anode Based on TiO2-PANI /ITO DSSC with β-carotene as Dye Sensitizer on its Structure, Absorbance, and Efficiency. Mater Today Proc. 17:1197–209 (2019).
31. Syafinar R, Gomesh N, Irwanto M, Fareq M, Irwan YM. Chlorophyll Pigments as Nature Based Dye for Dye-Sensitized Solar Cell (DSSC). Energy Procedia. 79:896–902 (2015).
32. Sinha D, De D, Ayaz A. Performance and stability analysis of curcumin dye as a photo sensitizer used in nanostructured ZnO based DSSC. Spectrochim Acta A Mol Biomol Spectrosc. 193:467–74 (2018).
33. Seithtanabutara V, Chumwangwapee N, Suksri A, Wongwuttanasatian T. Potential investigation of combined natural dye pigments extracted from ivy gourd leaves, black glutinous rice and turmeric for dye-sensitised solar cell. Heliyon. 9(11):e21533 (2023).
34. Seithtanabutara V, Chumwangwapee N, Suksri A, Wongwuttanasatian T. Potential investigation of combined natural dye pigments extracted from ivy gourd leaves, black glutinous rice and turmeric for dye-sensitised solar cell. Heliyon. 9(11):e21533 (2023).
35. Khan MJ, Ahirwar A, Sirotiya V, Rai A, Varjani S, Vinayak V. Nanoengineering TiO 2 for evaluating performance in dye sensitized solar cells with natural dyes. RSC Adv. 13(32):22630–8 (2023).
36. Hsu CY, Al-Salman HNK, Mahmoud ZH, Ahmed RM, Dawood AF. Improvement of the photoelectric dye sensitized solar cell performance using Fe/S–TiO2 nanoparticles as photoanode electrode. Sci Rep. 14(1):4931 (2024).
37. Ren A, Zhang W, Thomas HG, Barish A, Berry S, Kiel JS, et al. A Tannic Acid-Based Medical Food, Cesinex®, Exhibits Broad-Spectrum Antidiarrheal Properties: A Mechanistic and Clinical Study. Dig Dis Sci. 57(1):99–108 (2012).
38. Baldwin A, Booth BW. Biomedical applications of tannic acid. J Biomater Appl. 36(8):1503–23 (2022).
39. Stepczyńska M, Rytlewski P, Moraczewski K, Pawłowska A, Karasiewicz T. Novel Biocomposite of Starch and Flax Fiber Modified with Tannic Acid with Biocidal Properties. Polymers (Basel). 16(8):1108 (2024).
40. Bij KE, Horváth C, Melander WR, Nahum A. Surface silanols in silica-bonded hydrocarbonaceous stationary phases. J Chromatogr A. 203:65–84 (1981).
41. Che Lah NA, Kamaruzaman A. The physico-chemical and antimicrobial properties of nano ZnO functionalised tannic acid. Sci Rep. 14(1):18596 (2024).
42. Daré RG, Kolanthai E, Neal CJ, Fu Y, Seal S, Nakamura C V., et al. Cerium Oxide Nanoparticles Conjugated with Tannic Acid Prevent UVB-Induced Oxidative Stress in Fibroblasts: Evidence of a Promising Anti-Photodamage Agent. Antioxidants. 12(1):190 (2023).
43. Lopes LCS, Brito LM, Bezerra TT, Gomes KN, Carvalho fada, Chaves MH, et al. Silver and gold nanoparticles from tannic acid: synthesis, characterization and evaluation of antileishmanial and cytotoxic activities. An Acad Bras Cienc. 90(3):2679–89 (2018).
44. Ako RT, Ekanayake P, Young DJ, Hobley J, Chellappan V, Tan AL, et al. Evaluation of surface energy state distribution and bulk defect concentration in DSSC photoanodes based on Sn, Fe, and Cu doped TiO2. Appl Surf Sci. 351:950–61 (2015).
45. Zhou P, Lin B, Chen R, An Z, Chen X, An Q, et al. Effect of Extending the Conjugation of Dye Molecules on the Efficiency and Stability of Dye-Sensitized Solar Cells. ACS Omega. 6(44):30069–77 (2021).
46. Obraztsov I, Kutner W, D’Souza F. Evolution of Molecular Design of Porphyrin Chromophores for Photovoltaic Materials of Superior Light‐to‐Electricity Conversion Efficiency. Solar RRL. 1(2) (2017).
47. Sun X, Jiang S, Huang H, Li H, Jia B, Ma T. Solar Energy Catalysis. Angewandte Chemie International Edition. 61(29) (2022).
48. Hameed F, Maity A, Francis VS, Gavvalapalli N. Pyrazinacene conjugated polymers: a breakthrough in synthesis and unraveling the conjugation continuum. Chem Sci. 15(11):4054–67 (2024).
49. Tang J, Xie T, Geng J, Hua J, Wang Z. Rearrangement Strategy for the Preparation of Polymers With π-Conjugated Structures. Front Chem. 9 (2021).
50. Elgiddawy N, Elnagar N, Korri-Youssoufi H, Yassar A. π-Conjugated Polymer Nanoparticles from Design, Synthesis to Biomedical Applications: Sensing, Imaging, and Therapy. Microorganisms. 11(8):2006 (2023).
51. Block H, Cowd MA, Walker SM. Copolymerization of phenylethyne with maleic anhydride. Polymer (Guildf). 13(11):549–51 (1972).
52. Sahiner N, Sagbas S, Aktas N. Single step natural poly(tannic acid) particle preparation as multitalented biomaterial. Materials Science and Engineering: C. 49:824–34 (2015).
53. Sahiner N, Sagbas S, Aktas N, Silan C. Inherently antioxidant and antimicrobial tannic acid release from poly(tannic acid) nanoparticles with controllable degradability. Colloids Surf B Biointerfaces. 142:334–43 (2016).
54. Destari M, Hardeli H. Peningkatan efisiensi sensitized solar cell (dssc) menggunakan pelapisan tio2 doping zno dengan zat warna poli tanin. CHEDS: Journal of Chemistry, Education, and Science. 7(2):204–9 (2023).
55. Subriadi HPI, Hardeli H. Peningkatan Efisiensi Poli Tanin Sebagai Dye Pada Dye Sensitized Solar Cell Menggunakan Crosslinker Glutaraldehyde. REACTOR: Journal of Research on Chemistry and Engineering. 4(1):1 (2023).
56. Sathishkumar G, Gopinath K, Zhang K, Kang ET, Xu L, Yu Y. Recent progress in tannic acid-driven antibacterial/antifouling surface coating strategies. J Mater Chem B. 10(14):2296–315 (2022).
57. Ye J, Wei X, Fan K, Liu Y, Xia S. Evolving trends in tannic acid-modified thin-film composite membranes: A comprehensive review. J Memb Sci. 713:123257 (2025).
58. Chen C, Yang H, Yang X, Ma Q. Tannic acid: a crosslinker leading to versatile functional polymeric networks: a review. RSC Adv. 12(13):7689–711 (2022).
59. Hamadanian M, Safaei-Ghomi J, Hosseinpour M, Masoomi R, Jabbari V. Uses of new natural dye photosensitizers in fabrication of high potential dye-sensitized solar cells (DSSCs). Mater Sci Semicond Process. 27:733–9 (2014).
60. Gülçin İ, Huyut Z, Elmastaş M, Aboul-Enein HY. Radical scavenging and antioxidant activity of tannic acid. Arabian Journal of Chemistry. 3(1):43–53 (2010).
61. Liu R, Zhu J, Luo J, Liu X. Synthesis and application of novel UV-curable hyperbranched methacrylates from renewable natural tannic acid. Prog Org Coat. 77(1):30–7 (2014).
62. Martin JR, Patil P, Yu F, Gupta MK, Duvall CL. Enhanced stem cell retention and antioxidative protection with injectable, ROS-degradable PEG hydrogels. Biomaterials. 263:120377 (2020).
63. Hassan MdM, Martin AD, Thordarson P. Macromolecular crowding and hydrophobic effects on Fmoc-diphenylalanine hydrogel formation in PEG : water mixtures. J Mater Chem B. 3(48):9269–76 (2015).
64. Abisharani JM, DineshKumar R, Devikala S, Arthanareeswari M, Ganesan S. Influence of 2,4-Diamino-6-Phenyl-1-3-5-triazine on bio synthesized TiO 2 dye-sensitized solar cell fabricated using poly (ethylene glycol) polymer electrolyte. Mater Res Express. 7(2):025507 (2020).
65. Kumar Rout S, Padhi P, Biswal M, Debata S. A Comparative Study of a Novel Technique for the Fabrication of Dye Sensitized Solar Cells Using NanoTiO2 and Different Dyes. Research & Reviews: Journal of Material Sciences. 06(01) (2018).
66. Joshi P, Lawaju U, K.C. A, Nakarmi M, Pradhan R. Characterization of carbon derived from candle by flame-soot method for counter electrodes of dye-sensitized solar cells. BIBECHANA. 20(3):205–12 (2023).
67. Subriadi HPI, Hardeli H. Peningkatan Efisiensi Poli Tanin Sebagai Dye Pada Dye Sensitized Solar Cell Menggunakan Crosslinker Glutaraldehyde. REACTOR: Journal of Research on Chemistry and Engineering. 4(1):1 (2023).
68. Utami RWN, Dewi T, Indrayani. Bio-Inspired Solar Power: Natural Dyes and the Advancements of Dye-Sensitized Solar Cells. In: 2024 International Conference on Electrical and Information Technology (IEIT). IEEE; p. 42–7 (2023).
69. Umayya DR, Hardeli H. Peningkatan efisiensi dye sensitized solar cell (dssc) menggunakan poli tanin. CHEDS: Journal of Chemistry, Education, and Science. 7(2):216–20 (2023).
70. Genitori N, Di Marco G. Synthetic, natural and bioinspired dyes as TiO2 sensitizers in sustainable solar cells. In: Titanium Dioxide (Tio₂) and Its Applications. Elsevier;. p. 169–209 (2021).
71. Badawy SA, Abdel-Latif E, Elmorsy MR. Tandem dye-sensitized solar cells achieve 12.89% efficiency using novel organic sensitizers. Sci Rep. 14(1):26072 (2024).
72. Pan Z, Leem G, Cekli S, Schanze KS. Conjugated Polyelectrolyte-Sensitized TiO 2 Solar Cells: Effects of Chain Length and Aggregation on Efficiency. ACS Appl Mater Interfaces. 7(30):16601–8 (2015).
73. Zhou P, Lin B, Chen R, An Z, Chen X, An Q, et al. Effect of Extending the Conjugation of Dye Molecules on the Efficiency and Stability of Dye-Sensitized Solar Cells. ACS Omega. 6(44):30069–77 (2021).
Downloads
Published
How to Cite
Issue
Section
Citation Check
License
This work is licensed under a Creative Commons Attribution 4.0 International License.
Please find the rights and licenses in Jurnal Riset Kimia (J. Ris. Kim). By submitting the article/manuscript of the article, the author(s) agree with this policy. No specific document sign-off is required.
1. License
The use the article will be governed by the Creative Commons Attribution license as currently displayed on Creative Commons Attribution 4.0 International License.Â
2. Author(s)' Warranties
The author warrants that the article is original, written by stated author(s), has not been published before, contains no unlawful statements, does not infringe the rights of others, is subject to copyright that is vested exclusively in the author and free of any third party rights, and that any necessary written permissions to quote from other sources have been obtained by the author(s).
3. User Rights
Under the Creative Commons license, the journal permits users to copy, distribute, and display the material for any purpose. Users will also need to attribute authors and J. Ris. Kim on distributing works in the journal and other media of publications.
4. Rights of Authors
Authors retain all their rights to the published works, such as (but not limited to) the following rights;
- Copyright and other proprietary rights relating to the article, such as patent rights,
- The right to use the substance of the article in own future works, including lectures and books,
- The right to reproduce the article for own purposes,
- The right to self-archive the article,
- The right to enter into separate, additional contractual arrangements for the non-exclusive distribution of the article's published version (e.g., post it to an institutional repository or publish it in a book), with an acknowledgment of its initial publication in this journal.
5. Co-Authorship
If the article was jointly prepared by more than one author, any authors submitting the manuscript warrants that he/she has been authorized by all co-authors to be agreed on this copyright and license notice (agreement) on their behalf, and agrees to inform his/her co-authors of the terms of this policy. J. Ris. Kim will not be held liable for anything that may arise due to the author(s) internal dispute. J. Ris. Kim will only communicate with the corresponding author.
![](https://i1.wp.com/www.internetgeography.net/wp-content/uploads/2017/11/word-doc-icon.png"){kind=icon}
